Freeze drying has a deleterious effect on the viability of microorganisms. In front of this difficulty, the present study adopts response surface methodology to optimize the chemical compositions of protective agents to seek for maximum viability of Bifidobacterium longum BIOMA 5920 during freeze-drying. Through the compara- tive analysis of single protectant, the complex protective agents show better effect on the Bifidobacterium viability. Human-like collagen (HLC), trehalose and glycerol are confirmed as significant factors by Box-Behnken Design. The optimized formula for these three variables is tested as follows: HLC 1.23%, trehalose 11.50% and glycerol 4.65%. Under this formula, the viability is 88.23%, 39.67% higher in comparison to the control. The viable count is 1.07×10 9 cfu·g-1 , greatly exceeding the minimum viable count requirement (10 6 cfu·g-1 ).
The effects of L-cysteine concentration on biohydrogen production by Enterobacterium Bacterium M580 were investigated in batch cultivation.The experimental results showed that L-cysteine could enhance the cell growth,hydrogen production rate and hydrogen yield when its concentration was less than 500 mg·L-1,while it had negative effects when its concentration was higher than 500 mg·L-1.The hydrogen production was the highest 1.29 mol·mol-1(H2/glucose) when 300 mg·L-1L-cysteine was added into the culture,and the yield was 9.4% higher than that in the control.The oxidation-reduction potential(ORP) ,which was influenced by L-cysteine,also affected hydrogen production.The ORP values were in the range-300 mV to-150 mV when the L-cysteine concentration was higher than 500 mg·L-1.Although the ORP in this range was favorable for hydrogen production,it was not suitable for the biomass growth.Hence,less hydrogen was produced.When the L-cysteine concentration was lower than 500 mg·L-1,the ORP was more suitable for both biomass growth and hydrogen production.In addition,at least 91%glucose was consumed when L-cysteine was added to the culture media,compared to the 97.37% consumption without L-cysteine added.
